Scale-up of fluidized bed reactor for treatment of commercial laundry wastewater plus domestic sewage: optimization of operational conditions

• Grant number: 15/02640-2
• Support Opportunities: Scholarships in Brazil - Doctorate
• Start date: December 01, 2015
• End date: November 30, 2018
• Field of knowledge: Engineering - Sanitary Engineering - Water Supply and Wastewater Treatment
• Principal Investigator: Maria Bernadete Amâncio Varesche
• Grantee: Thaís Zaninetti Macedo Carmelo
• Host Institution: Escola de Engenharia de São Carlos (EESC). Universidade de São Paulo (USP). São Carlos , SP, Brazil

Abstract

The LAS (alkylbenzene linear sulfonate) is the most widely used surfactant worldwide. Its presence in the environment damages the public and environmental health. Among the reactors setups applied for the LAS removal has been obtained satisfactory results with application of the fluidized bed reactor (FBR). To date, most of these studies were performed in bench scale (volume close to 1 L) to diluted commercial laundry wastewater. The purpose of the present study is the scale-up of the FBR. Moreover, it is intended to treat commercial laundry wastewater in combination with domestic sewage, in order to evaluate the actual composition of what is usually discharged into the environment. In order to evaluate the influence of the presence of ethanol as a co-substrate in LAS degradation kinetics, kinetic parameters of degradation of the anionic surfactant will be obtained through bath tests in the presence and absence of that alcohol. The fluidized bed reactor will be operated in enlarged scale in four operating phases differentiated by the HRT: 18h, 14h, 12h and 8h for LAS concentration (dilution of the commercial laundry in domestic sewage) determined according to the results of the kinetics tests. The greatest challenges in scaling - ups is the difficulty of maintaining the mass transfer. The upflow velocity has a direct influence on this parameter, therefore, it will be tested over two expansion/fluidization velocities (vf) of the bed, besides that one established in all steps (1,3vmf), for the HRT in that phase with highest LAS removal efficiency . Through hydrodynamic tests is intended to measure the flow regime and identify flow anomalies to different HRT and flow velocities applied. Physico-chemical characterization of laundry wastewater and domestic sewage will be performed prior their use in the bath tests and reactor feeding. Periodic monitoring analyzes of the influent and effluent of the reactor will be done, such as COD, pH, alkalinity, volatile organic acids, total volatile solids and LAS. Biomass sample will be taken fot the HRT with the highest LAS removal efficiency , including the tree different flow velocities. Kinetic tests as well as inoculation of the reactor in enlarged scale will be made with biomass from activated sludge systems. It is an original research, since it is intended to identify in scale-up a lower HRT (hydraulic retention time) than those used by researchers from the Laboratory of Biological Processes Group (LPB) of the EESC-USP.

Scientific publications

(9)

(References retrieved automatically from Web of Science and SciELO through information on FAPESP grants and their corresponding numbers as mentioned in the publications by the authors)

GRANATTO, CAROLINE F.; GROSSELI, GUILHERME M.; SAKAMOTO, ISABEL K.; FADINI, PEDRO S.; VARESCHE, MARIA BERNADETE A.. Influence of metabolic cosubstrates on methanogenic potential and degradation of triclosan and propranolol in sanitary sewage. Environmental Research, v. 199, AUG 2021. (15/02640-2)

GRANATTO, CAROLINE F.; GROSSELI, GUILHERME M.; SAKAMOTO, ISABEL K.; FADINI, PEDRO S.; VARESCHE, MARIA BERNADETE A.. Influence of cosubstrate and hydraulic retention time on the removal of drugs and hygiene products in sanitary sewage in an anaerobic Expanded Granular Sludge Bed reactor. Journal of Environmental Management, v. 299, DEC 1 2021. (14/50951-4, 15/02640-2)

PIRETE, LUCIANA DE MELO; CAMARGO, FRANCIELE P.; DORNELLES, HENRIQUE S.; GRANATTO, CAROLINE F.; SAKAMOTO, ISABEL K.; GROSSELI, GUILHERME M.; FADINI, PEDRO S.; SILVA, EDSON LUIZ; AMANCIO VARESCHE, MARIA BERNADETE. Biodegradation of diclofenac and ibuprofen in Fluidized Bed Reactor applied to sanitary sewage treatment in acidogenic and denitrifying conditions. JOURNAL OF WATER PROCESS ENGINEERING, v. 49, p. 11-pg., 2022-06-27. (15/02640-2, 14/50951-4)

MACEDO, THAIS ZANINETTI; SILVA, EDSON LUIZ; SAKAMOTO, ISABEL KIMIKO; ZAIAT, MARCELO; VARESCHE, MARIA BERNADETE A.. Influence of linear alkylbenzene sulfonate and ethanol on the degradation kinetics of domestic sewage in co-digestion with commercial laundry wastewater. Bioprocess and Biosystems Engineering, v. 42, n. 9, p. 1547-1558, SEP 2019. (15/02640-2, 15/06246-7)

GRANATTO, C. F.; MACEDO, T. Z.; GEROSA, L. E.; SAKAMOTO, I. K.; SILVA, E. L.; VARESCHE, M. B. A.. Scale-up evaluation of anaerobic degradation of linear alkylbenzene sulfonate from sanitary sewage in expanded granular sludge bed reactor. INTERNATIONAL BIODETERIORATION & BIODEGRADATION, v. 138, p. 23-32, MAR 2019. (15/02640-2)

MACEDO, THAIS ZANINETTI; DORNELLES, HENRIQUE DE SOUZA; DO VALLE MARQUES, ANA LUIZA; PALLADINODELFORNO, TIAGO; CENTURION, VITOR BONIN; DE OLIVEIRA, VALERIA MAIA; SILVA, EDSON LUIZ; AMANCIO VARESCHE, MARIA BERNADETE. The influence of upflow velocity and hydraulic retention time changes on taxonomic and functional characterization in Fluidized Bed Reactor treating commercial laundry wastewater in co-digestion with domestic sewage. BIODEGRADATION, v. 31, n. 1-2, APR 2020. (15/02640-2, 15/06246-7)

MACEDO, T. Z.; DELFORNO, T. P.; BRAGA, J. K.; OKADA, D. Y.; SILVA, E. L.; VARESCHE, M. B. A.. Robustness and Microbial Diversity of a Fluidized Bed Reactor Employed for the Removal and Degradation of an Anionic Surfactant from Laundry Wastewater. JOURNAL OF ENVIRONMENTAL ENGINEERING, v. 143, n. 9, SEP 2017. (15/02640-2)

GRANATTO, CAROLINE F.; GROSSELI, GUILHERME M.; SAKAMOTO, ISABEL K.; FADINI, PEDRO S.; VARESCHE, MARIA BERNADETE A.. Methanogenic potential of diclofenac and ibuprofen in sanitary sewage using metabolic cosubstrates. Science of The Total Environment, v. 742, p. 13-pg., 2020-11-10. (14/50951-4, 15/02640-2)

ROCHA, DANILO HENRIQUE DONATO; SAKAMOTO, ISABEL KIMIKO; VARESCHE, MARIA BERNADETE AMANCIO. Evaluation of significant factors in hydrogen production and volatile fatty acids in co-fermentation of citrus peel waste and processing wastewater. FUEL, v. 354, p. 15-pg., 2023-12-15. (15/02640-2)

Academic Publications

(References retrieved automatically from State of São Paulo Research Institutions)

CARMELO, Thaís Zaninetti Macedo. Fluidized bed reactor upscale for treatment of commercial laundry wastewater combined with domestic sewage: optimization of operational conditions and taxonomic and functional characterization of microorganisms in biofilm. 2019. Doctoral Thesis - Universidade de São Paulo (USP). Escola de Engenharia de São Carlos (EESC/SBD) São Carlos.